Neutron radiography was used to quantify the steady-state water content and its distribution in a $50 cm2$ operating proton exchange membrane fuel cell. It was observed that the liquid water distribution near the corners of the gas-flow channels (GFCs) is influenced by the local gas-flow velocity as determined by the cathode stoichiometric flow ratio. At low velocity, the distribution of liquid water down the channel was found to be fairly uniform with only a slight reduction in liquid water content at the exit of the GFC corners. It was further observed that as the cathode gas-flow velocity is increased, a noticeable pattern develops in which liquid water is concentrated at the entrance to the GFC corners and becomes depleted in the corner and near the exit of the corner; liquid water content again increases further down the channel away from the corners. A single-phase computational fluid dynamics (CFD) model was developed and employed to help explain the observed water-distribution patterns. Flow-fields computed from our CFD model reveal recirculation regions in the GFC corners as well as in the areas of increased local gas-flow velocity, which help explain the experimentally observed liquid water distribution.

1.
Kramer
,
D.
,
Lehmann
,
E.
,
Frei
,
G.
,
Vontobel
,
P.
,
Wokaun
,
A.
, and
Scherer
,
G. G.
, 2005, “
An On–Line Study of Fuel Cell Behavior by Thermal Neutrons
,”
Nucl. Instrum. Methods Phys. Res. A
0168-9002,
542
, pp.
52
60
.
2.
Pekula
,
N.
,
Heller
,
K.
,
Chuang
,
P. A.
,
Turhan
,
A.
,
Mench
,
M. M.
,
Brenizer
,
J. S.
, and
Ünlü
,
K.
, 2005, “
Study of Water Distribution and Transport in a Polymer Electrolyte Fuel Cell Using Neutron Imaging
,”
Nucl. Instrum. Methods Phys. Res. A
0168-9002,
542
, pp.
134
141
.
3.
Hickner
,
M. A.
,
Siegel
,
N. P.
,
Chen
,
K. S.
,
McBrayer
,
D. N.
,
Hussey
,
D. S.
,
Jacobson
,
D. L.
, and
Arif
,
M.
, 2006, “
Real-Time Imaging of Liquid Water in an Operating Proton Exchange Membrane Fuel Cell
,”
J. Electrochem. Soc.
0013-4651,
153
(
5
), pp.
A902
A908
.
4.
Kramer
,
D.
,
Zhang
,
J.
,
Shimoi
,
R.
,
Lehmann
,
E.
,
Wokaun
,
A.
,
Shinohara
,
K.
, and
Scherer
,
G. G.
, 2005, “
In Situ Diagnostic of Two-Phase Flow Phenomena in Polymer Electrolyte Fuel Cells by Neutron Imaging: Part A. Experimental, Data Treatment, and Quantification
,”
Electrochim. Acta
0013-4686,
50
, pp.
2603
2614
.
5.
Trabold
,
T. A.
,
Owejan
,
J. P.
,
Jacobson
,
D. L.
,
Arif
,
M.
, and
Huffman
,
P. R.
, 2006, “
In Situ Investigation of Water Transport in an Operating PEM Fuel Cell Using Neutron Radiography: Part 1—Experimental Method and Serpentine Flow Field Results
,”
Int. J. Heat Mass Transfer
0017-9310,
49
, pp.
4712
4720
.
6.
Tüber
,
K.
,
Pócza
,
D.
, and
Hebling
,
C.
, 2003, “
Visualization of Water Buildup in the Cathode of a Transparent PEM Fuel Cell
,”
J. Power Sources
0378-7753,
124
, pp.
403
414
.
7.
Feindel
,
K. W.
,
LaRocque
,
L. P.-A.
,
Starke
,
D.
,
Bergens
,
S. H.
, and
Wasylishen
,
R. E.
, 2004, “
In Situ Observation of Water Production and Distribution in an Operating H2/O2 PEM Fuel Cell Assembly Using H1 NMR Microscopy
,”
J. Am. Chem. Soc.
0002-7863,
126
, pp.
11436
11437
.
8.
Sinha
,
P. K.
,
Halleck
,
P.
, and
Wang
,
C. -Y.
, 2006, “
Quantification of Liquid Water Saturation in a PEM Fuel Cell Diffusion Medium Using X-Ray Microtomography
,”
Electrochem. Solid-State Lett.
1099-0062,
9
(
7
), pp.
A344
A348
.
9.
Coppo
,
M.
, 2005, “
CFD Analysis and Experimental Investigation of Proton Exchange Membrane Fuel Cells
,” Ph.D. thesis, Politecnico di Torino, Turin, Italy.
10.
Coppo
,
M.
,
Siegel
,
N. P.
, and
von Spakovsky
,
M. R.
, 2007, “
On the Influence of Temperature on PEM Fuel Cell Operation
,”
J. Power Sources
0378-7753,
159
, pp.
560
569
.
11.
Chen
,
K. S.
,
Hickner
,
M. A.
, and
Noble
,
D. R.
, 2005, “
Simplified Models for Predicting the Onset of Liquid Water Droplet Instability at the Gas Diffusion Layer/Gas Flow Channel Interface
,”
Int. J. Energy Res.
0363-907X,
29
, pp.
1113
1132
.
12.
White
,
F. M.
, 1974,
Viscous Fluid Flow
,
McGraw-Hill
,
New York
, pp.
203
210
.