This paper proposes a method to calculate the characteristics of a coupled fluid dynamic journal and thrust bearing of a hard disk drive (HDD) spindle motor. The governing equations for the journal and thrust bearings are the two-dimensional Reynolds equations in the $θz$ and $rθ$ planes, respectively. The finite element method is appropriately applied to analyze the coupled bearing under the conditions of the continuity of mass and pressure at the interface between the journal and thrust bearings. The pressure in the coupled bearing was calculated by applying the Reynolds boundary condition. The validity of this application was verified by comparing the analytical results of the flying height at various rotating speeds with experimental results. The characteristics of the coupled journal and thrust bearing were also investigated due to the Reynolds and Half-Sommerfeld boundary conditions and the coupled and separate analysis. This research demonstrates that the proposed method can accurately and realistically describe the coupled fluid dynamic bearing in a HDD system.

1.
Zirkelback
,
N.
, and
San Andres
,
L.
, 1998, “
Finite Element Analysis of Herringbone Groove Journal Bearings: A Parametric Study
,”
ASME J. Tribol.
0742-4787,
120
, pp.
234
240
.
2.
Jang
,
G. H.
, and
Chang
,
D. I.
, 2000, “
Analysis of Hydrodynamic Herringbone Grooved Journal Bearing Considering Cavitation
,”
ASME J. Tribol.
0742-4787,
122
(
1
), pp.
103
109
.
3.
Zhang
,
Q. D.
,
Chen
,
S. X.
, and
Liu
,
Z. J.
, 1999, “
Design of a Hybrid Fluid Bearing System for HDD Spindles
,”
IEEE Trans. Magn.
0018-9464,
35
(
2
), pp.
821
826
.
4.
Zang
,
Y.
, and
Hatch
,
M. R.
, 1995, “
Analysis of Coupled Journal and Thrust Hydrodynamic Bearing Using Finite Volume Method
,”
ASME AISPS
,
1
, pp.
71
79
.
5.
Rahman
,
M.
, and
Leuthold
,
J.
, 1996, “
Computer Simulation of a Coupled Journal and Thrust Hydrodynamic Bearing Using a Finite-Element Method
,”
Proceedings of 25th Annual IMCSD Symposium
,
The Society
,
San Jose, CA
, pp.
103
112
.
6.
Jang
,
G. H.
, and
Yoon
,
J. W.
, 2002, “
Nonlinear Dynamic Analysis of a Hydrodynamic Journal Bearing Considering the Effect of a Rotating or Stationary Herringbone Groove
,”
ASME J. Tribol.
0742-4787,
124
(
2
), pp.
297
304
.
7.
Hamrock
,
B. J.
, 1994,
Fundamentals of Fluid Film Lubrication
,
McGraw-Hill
,
New York
, Chap. 10.
8.
Zheng
,
T.
, and
Hasebe
,
N.
, 2000, “
Calculation of Equilibrium Position and Dynamic Coefficients of a Journal Bearing Using Free Boundary Theory
,”
ASME J. Tribol.
0742-4787,
122
(
3
), pp.
616
621
.
9.
Jang
,
G. H.
,
Oh
,
S. H.
, and
Lee
,
S. H.
, 2005, “
Experimental Study on Whirling, Flying and Tilting Motion of a 3.5in. FDB Spindle System
,”
Tribol. Int.
0301-679X,
38
(
6-7
), pp.
675
681
.