Abstract
The study focuses on monitoring influence of the alumina coatings on friction and stability of the microscale iron contacts by the smoothed particle hydrodynamics. The obtained results show a better stability and a higher value of the friction coefficient of the coated surface compared to those of the uncoated one. This study also supposes that in concern of stability of the surface the coating should be done with only the substrate surface accompanied with the roughness of the coating layer. The proportion of the coated particles is found to be strongly resulting in the friction properties, and the roughness of the coating layer also slightly results in those. The surface reaches the most stability at the proportion of around 70%.
Issue Section:
Coatings and Solid Lubricants
Keywords:
tribology,
iron contact,
alumina coating,
SPH simulation,
coatings,
friction,
hardness,
sliding
References
1.
Pantelis
, D. I.
, Psyllaki
, P.
, and Alexopoulos
, N.
, 2000
, “Tribological Behaviour of Plasma-Sprayed Al2O3 Coatings Under Severe Wear Conditions
,” Wear
, 237
(2
), pp. 197
–204
. 10.1016/S0043-1648(99)00324-52.
Erickson
, L. C.
, Hawthorne
, H. M.
, and Troczynski
, T.
, 2001
, “Correlations Between Microstructural Parameters, Micromechanical Properties and Wear Resistance of Plasma Sprayed Ceramic Coatings
,” Wear
, 250
(1–12
), pp. 569
–575
. 10.1016/S0043-1648(01)00608-13.
Ramm
, D. A. J.
, Clyne
, T. W.
, Sturgeon
, A. J.
, and Dunkerton
, S.
, 1994
, “Correlations Between Spraying Conditions and Microstructure for Alumina Coatings Produced by HVOF and VPS
,” Proceedings of 7th National Thermal Spray Conference
, C. C.
Berndt
, and S.
Sampath
, eds., Boston, MA
, June 1994
, ASM International
, pp. 239
–243
.4.
Xu
, X.
, Su
, Z. G.
, Liu
, S. Y.
, Shen
, Y. S.
, and An
, J.
, 2010
, “Comparative Studies on Friction and Wear Performance Between Glass-Fiber Reinforced Polyamide 66 Composite and Ductile Irons on Ceramic Al2O3 Counterface in Sucker Rod Centralizer Application
,” ISIJ Int.
, 50
(6
), pp. 900
–905
. 10.2355/isijinternational.50.9005.
Vaxevanidis
, N. M.
, Manolakos
, D. E.
, and Petropoulos
, G. P.
, 2004
, “Surface Integrity and Tribological Behavior of Plasma Sprayed Alumina Coatings on Steel and Aluminum Substrates
,” Tribology Ind.
, 26
(1–2
), p. 42
.6.
Korkut
, M. H.
, Küçük
, Y.
, Karaoðlanli
, A. C.
, Erdoðan
, A.
, Er
, Y.
, and Gök
, M. S.
, 2013
, “Effect of the Abrasive Grit Size on the Wear Behavior of Ceramic Coatings During a Micro-Abrasion Test
,” MTAEC9
, 47
(6
), p. 695
.7.
Sawyer
, W. G.
, Freudenberg
, K. D.
, Bhimaraj
, P.
, and Schadler
, L. S.
, 2003
, “A Study on the Friction and Wear Behavior of PTFE Filled With Alumina Nanoparticles
,” Wear
, 254
(5–6
), pp. 573
–580
. 10.1016/S0043-1648(03)00252-78.
Marsal
, A.
, Ansart
, F.
, Turq
, V.
, Bonino
, J. P.
, Sobrino
, J. M.
, Chen
, Y. M.
, and Garcia
, J.
, 2013
, “Mechanical Properties and Tribological Behavior of a Silica or/and Alumina Coating Prepared by Sol-Gel Route on Stainless Steel
,” Surf. Coat. Technol.
, 237
, pp. 234
–240
. 10.1016/j.surfcoat.2013.06.0379.
Akhtar
, K.
, Khan
, Z. U.
, Gul
, M.
, Zubair
, N.
, and Shah
, S. S. A.
, 2018
, “Electrodeposition and Characterization of Ni-Al2O3 Nanocomposite Coatings on Steel
,” J. Mater. Eng. Perform.
, 27
(6
), p. 2827
. 10.1007/s11665-018-3346-210.
Yan
, J.
, Guo
, Y.
, Wang
, Y.
, Zhou
, P.
, and Qiu
, J.
, 2018
, “A Comparison Study on Wear Behaviors of Mo and Al2O3-Mo Coatings From RT to 300 °C
,” Lubricants
, 6
(2
), p. 48
. 10.3390/lubricants602004811.
Gadhari
, P.
, and Sahoo
, P.
, 2014
, “Study of Tribological Properties of Electroless Ni–P–Al2O3 Composite Coatings
,” International Conference on Advances in Engineering & Technology—2014 (ICAET-2014)
, Singapore
, Mar. 29–30
, pp. 34
–37
.12.
Wu
, H.
, Jin
, Y.
, Nicoll
, A. R.
, and Barbezat
, G.
, 1994
, “Friction and Wear of a Plasma Sprayed Al2O3-40% ZrO2-Cast Iron System
,” Wear
, 176
(1
), pp. 49
–60
. 10.1016/0043-1648(94)90196-113.
Krishnamurthy
, N.
, Prashanthareddy
, M. S.
, Raju
, H. P.
, and Manohar
, H. S.
, 2012
, “A Study of Parameters Affecting Wear Resistance of Alumina and Yttria Stabilized Zirconia Composite Coatings on Al-6061 Substrate
,” ISRN Ceram.
, 2012
, pp. 1
–13
. 10.5402/2012/58589214.
Lakshmipathy
, J.
, and Kulendran
, B.
, 2014
, “Reciprocating Wear Behaviour of 7075Al/SiC and 6061Al/Al2O3 Composites: A Study of Effect of Reinforcement, Stroke and Load
,” Tribol. Ind.
, 36
(2
), p. 117
.15.
Zhou
, G.
, and Ding
, H.
, 2013
, “Wear Performance of Alumina-Reinforced Copper–Matrix Composites Prepared by Powder Metallurgy
,” Proc. Inst. Mech. Eng. J.
, 227
(9
), pp. 1011
–1017
. 10.1177/135065011247176916.
Akbarzadeh
, A.
, and Khonsari
, M. M.
, 2018
, “Effect of Untampered Plasma Coating and Surface Texturing on Friction and Running-in Behavior of Piston Rings
,” Coatings
, 8
(3
), p. 110
. 10.3390/coatings803011017.
Kwolek
, P.
, Krupa
, K.
, Obłoj
, A.
, Kocurek
, P.
, Wierzbinska
, M.
, and Sieniawski
, J.
, 2018
, “Tribological Properties of the Oxide Coatings Produced Onto 6061-T6 Aluminum Alloy in the Hard Anodizing Process
,” J. Mater. Eng. Perform.
, 27
(7
), pp. 3268
–3275
. 10.1007/s11665-018-3421-818.
Zhang
, D.
, Gou
, Y.
, Liu
, Y.
, and Guo
, X.
, 2013
, “A Composite Anodizing Coating Containing Superfine Al2O3 Particles on AZ31 Magnesium Alloy
,” Surf. Coat. Technol.
, 236
(57
), pp. 52
–57
. 10.1016/j.surfcoat.2013.04.05919.
Maveyraud
, C.
, Benz
, W.
, Sornette
, A.
, and Sornette
, D.
, 1999
, “Solid Friction at High Sliding Velocities: an Explicit Three-Dimensional Dynamical Smoothed Particle Hydrodynamics Approach
,” J. Geophys. Res.
, 104
(B12
), pp. 28769
–28788
. 10.1029/1999JB90021720.
Sang
, L. V.
, Yano
, A.
, Fujii
, S.
, Sugimura
, N.
, and Washizu
, H.
, 2018
, “Coarse-Grained Model for Spring Friction Study of Micron-Scale Iron by Smoothed Particle Hydrodynamics
,” EPL
, 122
(2
), p. 26004
. 10.1209/0295-5075/122/2600421.
Sang
, L. V.
, Yano
, A.
, Isohashi
, A.
, Sugimura
, N.
, and Washizu
, H.
, 2019
, “Smoothed Particle Hydrodynamics Study of Friction of the Coarse-Grained α-Al2O3/α-Al2O3 and α-Fe2O3/α-Fe2O3 Contacts in Behavior of the Spring Interfacial Potential
,” Tribol. Int.
, 135
, pp. 296
–304
. 10.1016/j.triboint.2019.03.01522.
Sang
, L. V.
, Yano
, A.
, Isohashi
, A.
, Sugimura
, N.
, and Washizu
, H.
, 2020
, “Friction and Friction Heat of Micronscale Iron
,” ASME J. Tribol.
, 142
(9
), p. 091702
. 10.1115/1.404681523.
Zeng
, J.
, Shen
, J.
, and Liu
, H.
, 2019
, “A Parametric Study of Dam Break Flow Feature Over a Dry Bed Using SPH Modeling
,” Proceedings of the 10th International Conference on Asian and Pacific Coasts (APAC 2019)
, Hanoi, Vietnam
, Sept. 25–28
, pp. 79
–86
.24.
Iwasawa
, M.
, Tanikawa
, A.
, Hosono
, N.
, Nitadori
, K.
, Muranushi
, T.
, and Makino
, J.
, 2016
, “Implementation and Performance of FDPS: A Framework for Developing Parallel Particle Simulation Codes
,” Publ. Astron. Soc. Japan
, 68
(4
), p. 54
. 10.1093/pasj/psw05325.
Khac
, B. C. T.
, Kim
, H. J.
, DelRio
, F. W.
, and Chung
, K. H.
, 2019
, “Operational and Environmental Conditions Regulate the Frictional Behavior of Two-Dimensional Materials
,” Appl. Surf. Sci.
, 483
, p. 34
. 10.1016/j.apsusc.2019.03.24926.
Li
, X.
, Wang
, A.
, and Lee
, K. R.
, 2018
, “Mechanism of Contact Pressure-Induced Friction at the Amorphous Carbon/Alpha Olefin Interface
,” NPJ Comput. Mater
, 4
(53
), p. 1
.27.
Li
, X.
, Wang
, A.
, and Lee
, K. R.
, 2019
, “Atomistic Understanding on Friction Behavior of Amorphous Carbonfilms Induced by Surface Hydrogenated Modification
,” Tribol. Int.
, 136
, pp. 446
–454
. 10.1016/j.triboint.2019.04.01928.
Sartwell
, B. D.
, Zemel
, J. N.
, Mcguire
, G. E.
, and Bresnock
, F. N.
, 1990
, Metallurgical Coatings and Thin Films
, Elsevier
, California
.29.
Erdemir
, A.
, 2000
, “A Crystal-Chemical Approach to Lubrication by Solid Oxides
,” Tribol. Lett.
, 8
(2/3
), p. 97
. 10.1023/A:101918310132930.
Ewen
, J. P.
, Restrepo
, S. E.
, Morgan
, N.
, and Dini
, D.
, 2017
, “Nonequilibrium Molecular Dynamics Simulations of Stearic Acid Adsorbed on Iron Surfaces With Nanoscale Roughness
,” Tribol. Int.
, 107
, p. 264
. 10.1016/j.triboint.2016.11.03931.
Wang
, J.
, Wang
, G. F.
, and Yuan
, W. K.
, 2018
, “The Statistical Characteristics of Static Friction
,” Int. J. Appl. Mech.
, 10
(08
), p. 1850087
. 10.1142/S175882511850087432.
Dyachkov
, S.
, Parshikov
, A.
, and Zhakhovsky
, V.
, 2015
, “Ejecta From Shocked Metals: Comparative Simulations Using Molecular Dynamics and Smoothed Particle Hydrodynamics
,” AIP Conference Proceedings
, Vol. 1793
, p. 100024
.33.
Chai
, Z.
, Liu
, Y.
, Lu
, X.
, and He
, D.
, 2014
, “Reducing the Adhesion and Friction Forces of Si by Coating Ultra-thin Al2O3 Films
,” RSC Adv.
, 4
(92
), pp. 51047
–51054
. 10.1039/C4RA06379A34.
Eiliat
, H.
, Nie
, X.
, Tjong
, J.
, and Villafuerte
, J.
, 2014
, “Outside-Engine Wear Study of Ceramic Coated Cylinder Wall Tribo-System
,” SAE Technical Paper 2014-01-0958
. 10.4271/2014-01-0958.35.
Hentoura
, K.
, Marsala
, A.
, Turq
, V.
, Weibel
, A.
, Ansart
, F.
, Sobrino
, J. M.
, Chen
, Y. M.
, Garcia
, J.
, Cardey
, P. F.
, and Laurent
, C.
, 2016
, “Carbon Nanotube/Alumina and Raphite/Alumina Composite Coatings on Stainless Steel for Tribological Applications
,” Mater. Today
, 8
, p. 118
.36.
Goel
, S.
, Björklund
, S.
, Curry
, N.
, Wiklund
, U.
, and Joshi
, S. V.
, 2017
, “Axial Suspension Plasma Spraying of Al2O3 Coatings for Superior Tribological Properties
,” Surf. Coat. Technol.
, 3
, pp. 80
–87
. 10.1016/j.surfcoat.2017.02.025Copyright © 2020 by ASME
You do not currently have access to this content.
